Description
IMER Mix 120 Plus (Mortarman) Vertical Shaft Mixer
The Mortarman 120+ is perfect for the 2-4 man construction crew. Why go through all the hassles of towing a mixer to a job site, when the Mortarman 120+ can make a wheelbarrow of mortar, stucco, grout, or dry pack cement every 3 minutes. In fact, vertical shaft mixers deliver so much mixing torque that the 120+ can out produce a 2 bag towable mixer when making dry pack cement.
Mix anywhere:
The 120+ can go anywhere just roll it through standard doorways. While the mixing action is neat and controlled. The mud stays in the drum, and the mix discharge is equally clean. Mix indoors without making a mess!
Reverse It:
If the material being mixed starts to clump up or separate, no problem just hit reverse for a few seconds...then back to forward. The ability to switch from forward to reverse ensures that all types of material mix well...Bring on the tough stuff!
Outlet:
The discharge of material is very controlled. Whether you need a trowel, a bucket or a wheelbarrow full of material...it’s all there with a twist of your arm.
Vertical shaft mixers rock!:
The paddles are always in the mix, working hard. Material is blended without air entrapment, and even stiff muds are mixed thoroughly and quickly.
- 2HP 110V motor providing tremendous power to the oil bath reduction gearbox, mix up all types of mortar, stucco, grout, dry pack, floor leveler, refractory mud, or specialty bagged material in just 3 minutes
- If the material being mixed starts to clump up or separate, no problem, just hit reverse for a few seconds, then back to forward to finish blending the batch.
- The mixing action is fast and furious, a batch of 3 cu. ft. is ready every 2-3 minutes
- The 120 Plus can go anywhere. It rolls right through standard doorways and its mixing action is very well controlled. The mud stays in the drum - mix indoors without creating a mess
- Controlled discharge, take out a hand full, a 5 gallon pail, or a wheelbarrow.
- The safety grate has bag splitters built into it, and when you lift the safety grate the 120 Plus stops automatically.
- New! Dust Grate captures bag dust and has a vaccum attachment for pulling dust out of the Mixer.
- Drum Capacity: 4.25 cu. ft.
- Batch output: 3 cu. ft.
- Drum diameter: 30"
- Maximum aggregate size: 3/8"
- Paddle speed: 38 RPM
- Mortor rating: 2 hp 110v, Single Phase
- Current draw: 15 amps
- Noise: 70 dB(A)
- Machine weight (crated): 286 lbs (310 lbs)
- Width: 30" (31")
- Length: 33" (35")
- Height: 50" (38")
What's Included:
- 2 hp 110v motor
- Hi-torque gearbox drive with reverse
- Hard solid wheel
- Loading wheels
- 4.25 cu. ft. drum capacity
- Vertical paddles good for mixing mortar, stucco and grout
A note about operating in cold air temperatures: If you are using your mixer in air temperatures below 40 degrees the high grade oil in the gearbox will thicken and slow the mixer or it may not start. In these conditions, warm up the mixer, especially the gearbox and it will run normally. Also, be sure to use 10 gauge electrical cord no longer than 50ft.
Optional Paddle Kit: Imer makes an optional paddle kit for the Imer Mix 120 Plus Mixer. This kit adds rubber wipers to the mixing paddles and are used for mixing colors or for expensive material as the wipers clean out the drum a little better, but are not needed as this mixer does a thorough mixing job without them. Click this link: Imer 120+ Mixing Paddles for more information and to purchase.
Options:
- Standard Grate (1194304)
- Dust Grate (1194302)
IMER Mix 120 Plus (Mortarman) Vertical Shaft Mixer Product Manual
